Product ID:ISOPROPYL ALCOHOL
MSDS Date:06/01/2000
FSC:6810
NIIN:00-286-5435
Status Code:A
MSDS Number: CLFVQ

Emergency Phone: 1-800-707-4555

Info Phone: 1-800-368-0050

Cage: UO546

Telephone: 916-941-3688

Cage: 1KH20

ISOPROPYL ALCOHOL

CAS: 67-63-0

RTECS: NT8050000

OSHA PEL 980 MG/M3;400 PPM

ACGIH TLV: 983 MG/M3;400 PPM

LD50 LC50 Mixture:ORAL RAT LD50 = 5045 MG/KG
Health Hazards Acute and Chronic:SKIN: REPEATED EXPOSURES TO THE SKIN
MAY RESULT IN BURNING ITCHING, REDNESS & DERMATITIS. EYES: LIQUID &
VAPOR CONTACT PRODUCES INTENSE STINGING & BURNING SENSATIONS. IT
HAS BEEN REPORTED THAT PROLONG ED CONTACT TO THE LIQUID MAY CAUSE
TEMPORARY DAMAGE TO THE EYES, BUT HEALING HAS BEEN PROMPT.
INHALATION: EXPOSURE CAN CAUSE RESPIRATORYY TRACT & THROAT
IRRITATION, HEADACHES, SHORTNESS OF BREATH & SY MPTOMS SIMILAR TO
INTOXICATION. OVEREXPOSURE CAN PRODUCE SEVERE CNS DEPRESSION, COMA
& POSSIBLY FATAL RESPIRATORY FAILURE. INGESTION: THE PROBABLE
LETHAL DOSE IN AN AN ADULT IS 240 ML BUT AS LITTLE AS 20 ML MAY
PRODUCE SYMPTOMS.
Effects of Overexposure:SKIN: BURNING ITCHING, REDNESS & DERMATITIS.
EYES: INTENSE STINGING & BURNING SENSATIONS. IT HAS BEEN REPORTED
THAT PROLONGED CONTACT TO THE LIQUID MAY CAUSE TEMPORARY DAMAGE TO
THE EYES, BUT HEALING HAS BEEN PROMPT. INHALATION: RESPIRATORYY
TRACT & THROAT IRRITATION, HEADACHES, SHORTNESS OF BREATH &
SYMPTOMS SIMILAR TO INTOXICATION. OVEREXPOSURE CAN PRODUCE SEVERE
CNS DEPRESSION, COMA & POSSIBLY FATAL RESPIRATORY FAILURE.
INGESTION: THE PROBABLE LETHAL DOSE IN AN AN ADULT IS 240 ML BUT AS
LITTLE AS 20 ML MAY PRODUCE SYMPTOMS. SYMPTOMS MAY INCLUDE NAUSEA,
ABDOMINAL PAIN, BLEEDING AND CNS DEPRE SSION. DELAYED EFFECTS: NONE
KNOWN.

First Aid:SKIN: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. REMOVE
CONTAMINATED CLOTHNG. WASH CLOTHING BEFORE REUSE. EYES: FLUSH WITH
WATER FOR AT LEAST 15 MINUTES. IF IRRITATION PERSISTS, GET MEDICAL
ASSISTANCE. INHALATION: REMOVE FROM EXPOSURE AREA TO FRESH AIR. IF
VICTIM IS NOT BREATHING ADMINISTER ARTIFICIAL RESPIRATION ACCORDING
TO YOUR LEVEL OF TRAINING AND OBTAIN PROFESSIONAL MEDICAL
ASSISTANCE IMMEDIA TELY. INGESTION: IF PATIENT IS CONSCIOUS, RINSE
MOUTH WITH WATER. DO NOT INDUCE VOMITING UNLESS INSTRUCTED TO DO SO
BY A PHYSICIAN, GET IMMEDIATE MEDICAL ATTENTION. ADVICE TO
PHYSICIAN: NO SPECIFIC IN STRUCTIONS. TREAT SYMPTOMATICALLY.

Flash Point Method:CC
Flash Point:=11.7C, 53.F
Autoignition Temp:=398.9C, 750.F
Lower Limits:2.0
Upper Limits:12.0
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE OR ALCOHOL RESISTANT
FOAM. WATER MAY BE INEFFECTIVE. WATER SPRAY MAY BE USED TO REDUCE
VAPORS AND TO COOL CONTAINERS EXPOSED TO FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS. DO
NOT RELEASE RUNOFF FROM FIRE CONTROL METHODS TO SEWER OR WATERWAYS.
KEEP FIRE EXPOSED CONTAINERS COOL AND REDUCE VAPORS WITH WATER
SPRAY.
Unusual Fire/Explosion Hazard:FIRE HAZARD WHEN EXPOSED TO HEAT, FLAME
OR OXIDIZERS. VAPORS ARE HEAVIER THAN AIR AND MAY TRAVEL A
CONSIDERABLE DISTANCE TO AN IGNITION SOURCE AND FLASHBACK. VAPOR
MIXTURES ARE EXPLOSIVE.

Spill Release Procedures:(ALWAYS WEAR RECOMMENDED PERSONAL PROTECTIVE
EQUIPMENT). ELIMINATE SOURCES OF IGNITION. ISOLATE THE SPILL AREA.
STOP LEAK IN A SAFE & PRACTICAL MANNER. ( IF LEAK CANNOT BE STOPPED
EASILY & SAFELY, ADV ISE TRAINED EMERGENCY RESPONSE PERSONNEL OF
THE SITUATION.). USING INERT MATERIAL (SUCH AS GROUND CORNCOBS)
DIKE THE SPILLED SOLVENT TO PREVENT IT FROM RUNNING INTO DRAINS OR
WATERWAYS.

Handling and Storage Precautions:(ALWAYS WEAR RECOMMENDED PERSONAL
PROTECTIVE EQUIPMENT). STORE IN A COOL, DRY, WELL VENTILATED AREA,
AWAY FROM HEAT, OPEN FLAME OR OTHER IGNITION SOURCES. USE GOOD
PERSONAL HYGIENE & HOUSEKEEPING PRAC TICES. STORE IN AN AREA
DESIGNED FOR STORAGE OF FLAMMABLE LIQUIDS.
Other Precautions:PROTECT CONTAINERS FROM PHYSICAL DAMAGE. FLAMMABLE
LIQUID & VAPOR. ONCE LIQUID SOLVENT HAS BEEN COMPLETELY DISPENSED,
CONTAINERS WHICH APPEAR "EMPTY" SHOULD BE HANDLED IN THE SAME
MANNER AS WHEN THEY WERE "FULL" OF LIQUID SOLVENT. AVOID CONTACT
WITH SKIN, EYES & CLOTHING; AVOID BREATHING VAPOR OR M IST.

Respiratory Protection:SEEK PROFESSIONAL ADVICE PRIOR TO RESPIRATOR
SELECTION/USE. FOLLOW OSHA RESPIRATOR REGULATIONS (29 CFR 1910.134)
& IF NECESSARY, WEAR A MSHA/NIOSH-APPROVED RESPIRATOR. FOR
EMERGENCY OR NON-ROUTINE OPE RATIONS (CLEANING SPILLS, OR STORAGE
TANKS), WEAR A SCBA. WARNING! AIR-PURIFYING REPIRATORS DO NOT
PROTECT WORKERS IN OXYGEN-DEFICIENT ATMOSPHERE.
Ventilation:PROVIDE GENERAL OR LOCAL EXHAUST VENTILATION SYSTEMS TO
MAINTAIN AIRBORNE CONCENTRAION BELOW PERMISSIBLE TLV LEVELS. LOCAL
EXHAUST VENTILATION IS PREFERRED
Protective Gloves:CHEMICAL RESISTANT GLOVES
Eye Protection:SAFETY GLASSES ARE CONSIDERED MINIMUM PROTECTION.
Other Protective Equipment:GOGGLES OR FACE SHIELD MAY BE NECESSARY
DEPENDING ON QUANTITY OF MATERIAL & CONDITIONS OF USE. IMPERVIOUS
COVERALLS, CHEMICAL RESISTANT BOOTS AND APRON.
Work Hygienic Practices:THIS MATERIAL SHOULD BE USED IN CLOSE PROXIMITY
TO EYEWASH STATION AND SAFETY SHOWER. USE APPROPRIATE PERSONAL
HYGIENE AFTER HANDLING THIS MATERIAL. DO NOT SMOKE IN THE VICINITY
OF FLAMMABLE MATERIALS
Supplemental Safety and Health

HCC:F2
Boiling Pt:=82.3C, 180.1F
Melt/Freeze Pt:=-88.C, -126.4F
Vapor Pres:@20C: 33 MMHG
Vapor Density:2.1
Spec Gravity:0.785 @25C
Evaporation Rate & Reference:~3 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID; SLIGHT ALCOHOL ODOR
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, STRON ACIDS, REACTIVE METALS, INCLUDING ALUMINUM.
FORMS KETONES IN PRESENCE OF OXYGEN.
Stability Condition to Avoid:HEAT, SPARKS & FLAME. DIRECT SUNLIGHT.
STABLE AT ROOM TEMPERATURES. AVOID CONTACT W/ IGNITION SOURCES.
VAPORS ARE FLAMMABLE. CONTAINERS MAY RUPTURE VIOLENTLY IN FIRE .
Hazardous Decomposition Products:INCOMPLETE COMBUSTION CAN GENERATE
CARBON MONOXIDE AND OTHER HAZARDOUS GASES.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:THE INFORMATION OFFERED HERE IS FOR THE PRODUCT
AS SHIPPED. USE &/OR ALTERATIONS TO THE PRODUCT SUCH AS MIXING W/
OTHER MATERIALS MAY SIGNIFICANTLY CHANGE THE CHARACTERISTICS OF THE
MATERIAL & ALTER T HE RCRA CLASSIFICATION & THE PROPER DISPOSAL
METHOD. UNUSED PRODUCT IS A RCRA HAZARDOUS WASTE IF DIS CARDED.
RCRA ID NUMBER IS D001.

Toxicological Information:SKIN IRRITATION (RABBIT)= 500 MG - MILD. EYE
IRRITATION: 10 MG - MODERATE; 100 MG - MODERATE.

======================================================================
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:RELATIVELY BIODEGRADEABLE. LC50 PIMEPHALES PROMELAS (FATHEAD
MINNOWS) 11,160 MG/1/24 HR (STATIC BIOASSAY IN LAKE SUPERIOR AT
18-22 C. LC50 10.4 G/1/96 HR.

Transport Information:PSN: ISOPRPYL ALCOHOL, 3, UN1219, II. LABEL:
FLAMMABLE LIQUID.

SARA Title III Information:THERE IS NO RQ AND TPQ FOR ISOPROPANOL. SARA
313 TOXIC CHEMICALS: ISOPRPYL ALCOHOL (ONLY PERSONS WHO MANUFACTURE
BY STRONG ACID PROCESS ARE SUBJECT TO REPORTING REQUIREMENTS). SARA
311 HAZARD CLASS: I MMEDIATE, AND FIRE.
Federal Regulatory Information:TSCA INVETORY STATUS: LISTED ON
INVENTORY.
State Regulatory Information:STATE RIGHT TO KNOW: NONE LISTED. FOREIGN
INVENTORY STATUS: LISTED ON THE CANADIAN DSL AND EINECS.